Method for assembling Tricycle Motorcycle battery

After the Tricycle Motorcycle battery is repaired, the Tricycle Motorcycle battery pack must be assembled, otherwise the repair effect of the Gasoline Tricycle will not be achieved. The smaller the capacity difference of the Tricycle Motorcycle batteries connected in series during assembly, the better. The difference between medium and high capacity and low capacity should be less than 6%, the capacity distribution should be reasonable and continuous, avoid sudden high and low, and the voltage difference of the open circuit terminal of the Tricycle Motorcycle battery should be within ±0.5V.

1. Three-wheel motorcycle battery matching method
Before assembly, the charging and discharging conditions of the Tricycle Motorcycle battery should be fully checked in advance. After three chargings and two dischargings, the curve and capacity are exactly the same, and the open circuit voltage after charging and discharging is also the same. If the Tricycle Motorcycle battery is assembled into a group, Their synchronization is definitely good in use. When the discharge is terminated at the same time and the charge is fully charged at the same time, the maximum energy can be fully exerted, and the last time reaches the end of life.
2. How to replace the battery when matching
(1) Replace the old three-wheel motorcycle battery with the old three-wheel motorcycle battery: choose an old three-wheel motorcycle battery that has not been scrapped, and match it with the remaining two three-wheel motorcycle batteries in the original group. The open circuit voltage is the same as or close to the remaining two tricycle batteries in the original group, and will continue to be used after assembly until the life of the tricycle battery ends.
It is unscientific and uneconomical to replace the old Tricycle Motorcycle battery with a new Tricycle Motorcycle battery. The old and new Tricycle Motorcycle batteries will never work synchronously. Not only the characteristics are very different, but also the charging and discharging terminal voltage is also different. Capacity is a big issue, and replacing old three-wheeler batteries with new ones is not feasible.
(2) Trade in the old for the new: the service life of the Tricycle Motorcycle battery pack is less than 1/3 of the annual life, and even only takes a short time. If a Tricycle Motorcycle battery becomes a problem and cannot be used after identification, it should In the above situation, choose to replace the new Tricycle Motorcycle battery or the used new Tricycle Motorcycle battery, but the difference should be reduced. The capacity difference is within 1%, and the voltage difference is within ±0.5V. The better the service life and charging and discharging performance of the motorcycle battery, the better the mileage of the Tricycle Motorcycle can be guaranteed.
The service life of the Gasoline Tricycle after repair is a major issue related to the significance of Gasoline Tricycle repair, which is closely related to the Gasoline Tricycle repair instrument used, the condition of the tricycle battery, and the repair method used.
The first is the repair effect of the Gasoline Tricycle repair instrument. Secondly, the repair method of the Gasoline Tricycle is also very important. The correct method is to use a special repair agent for the battery, remove the vulcanization with a pulse repair instrument, and then adjust it according to the actual capacity of the battery to prolong the service life of the battery. service life.
In addition, most of the scrapped Tricycle Motorcycle batteries are caused by the sulfation of the Tricycle Motorcycle battery, which leads to a decrease in capacity. This is also the time for the Gasoline Tricycle to be repaired. Lifespan of a motorcycle battery.