Tricycle With Cabin are developing extremely rapidly

The development momentum of Tricycle Motorcycle is extremely rapid. In recent years, the actual output every year has exceeded the social stock. This is an astonishing data. Deep discharge of lead-acid batteries used in cars only discharges in one direction during ignition. After ignition, the generator will automatically charge the battery, without causing battery depth. Discharge. It is impossible to charge an Tricycle With Cabin while riding, and the deep discharge often exceeds 60%. During deep discharge, the concentration of lead sulfate increases, and sulfation will be quite serious.

The cruising current of large-current discharge Tricycle Motorcycle for 20 kilometers is generally 4A. This value is already higher than the battery operating current in other fields, and the operating current of overspeeding and overloaded Tricycle Motorcycle is even greater. Battery manufacturers have conducted cycle life tests of 70% charging at 1C and 60% discharge at 2C. After such a life test, there are many batteries that can achieve a lifespan of 350 charge and discharge cycles, but the actual effects in use are far different. This is because high current operation increases the depth of discharge by 50%, and the battery will accelerate vulcanization. Therefore, the battery life of Tricycle With Cabin Motorcycle is shorter because the body of the Tricycle Motorcycle is too heavy and the operating current reaches more than 6A.
Batteries used in the field of backup power supply with high charging and discharging frequency will only discharge when there is a power outage. If the power is interrupted 8 times a year, to reach a life of 10 years, it only needs to achieve a charging cycle of 80 times, while an Tricycle With Cabin can have a life of 10 years. Charge and discharge cycles of more than 300 times are common.
Short-term charging: Since Tricycle Motorcycle are vehicles, they do not have much time to charge. To complete the 20-amp-hour charging of 36 volts or 48 volts within 8 hours, the charging voltage must be increased. When the charging voltage exceeds the analysis capacity of a single battery, When the oxygen voltage (2.35 volts) or hydrogen evolution voltage (2.42 volts) is exceeded, the battery will open the valve to exhaust due to excessive oxygen evolution, causing water loss, increasing the concentration of the electrolyte, and aggravating the sulfurization phenomenon of the battery. It cannot be charged in time after discharge. As a means of transportation, the charging and discharging of Tricycle Motorcycle are completely separated. It is difficult to charge in time after discharge. And the large amount of lead sulfate formed after discharge will be reduced to lead oxide if it is not charged for more than half an hour. Will sulfide to form crystals.