Use and maintenance of Tricycle With Cabin

During the use of Tricycle With Cabin, strengthening maintenance and upkeep, mastering simple parts maintenance knowledge, and developing good usage habits can extend the service life of the vehicle.

1. After using a new car for 1-2 weeks, it is generally necessary to conduct a comprehensive inspection of the entire vehicle, tighten and adjust the loose parts in time, and frequently check the rotating parts (rear axle, front axle, front fork), transmission (chain, sprocket) Check and maintain the relative moving parts (hand brake, foot brake), add lubricating oil in time, tighten the fastening parts in time, and adjust the chain tension in time.
2. Braking: Regularly adjust the foot brake and hand brake. The braking distance of the vehicle must be effectively controlled within 4 meters. At the same time, the brake power-off switch must be able to cut off power in a timely manner.
3. During the use of the motor, the commutator should be cleaned regularly and the brushes and planetary gears should be replaced regularly. Overloading the transmission is strictly prohibited. Pay attention to moisture-proofing to extend the service life of the motor. Generally, the brushes should be checked once every 2-3 months. If necessary, they should be replaced. Make timely adjustments. During high temperature seasons, it is recommended to open the protective ring on the motor to help dissipate heat, but it is not suitable in rainy days. All electrical components and circuit connection parts should be kept clean at all times to prevent oxidation and poor conductivity.
4. Charging precautions
① When the power supply voltage is low or the battery has been used for too long (performance deteriorates), the charging time cannot be converted to float charging for more than 10 hours. At this time, as long as the ammeter indication is close to zero, it means that the battery is sufficient and will not affect normal driving.
② The normal charging current shall not be greater than 18A. When it exceeds the safe value, the internal alarm device will beep continuously to remind you to reduce the charging current to ensure the safety of the charger and battery. Due to unstable power supply voltage, it is normal to beep occasionally, no adjustment is required.
5. Battery maintenance
①The surface of the battery should be kept dry and clean. Metal and other debris are not allowed to accumulate on it to prevent circuit breakage.
② Never run out of battery. Even if the vehicle is not used temporarily, it must be charged every 2-3 days, otherwise the battery life will be affected.
③If the battery is found to be depleted, it must be charged continuously for more than 36 hours before use, otherwise the battery will not be used for a long time.
④The battery should maintain a normal liquid level. If it is found to be short of liquid, distilled water should be added (before charging). It is prohibited to add charging liquid, replenishing liquid or other water quality.
6. Attention
①Due to the low temperature in winter and poor battery discharge, it is completely normal for the vehicle mileage to be only 60% of the normal range. Please do not misunderstand it as a battery quality problem.
② Our company is not responsible if the motor is burned due to failure to replace the brushes in time.