Various maintenance methods for Hydraulic Dumping Tricycle batteries?

October 09, 2024

1. Use the charger correctly

① Determine whether the AC power supply matches the input voltage of the charger.

A Tuktuk Tricycle using hydraulic system for unloading

② Determine whether the output voltage of the charger matches the rated voltage of the battery.

③ First plug the plug connecting the charger to the battery box, and then plug the AC power plug.

④ The charger is used indoors, and attention should be paid to moisture and vibration prevention. It is strictly forbidden to cover it during charging, and it should be placed in a ventilated and heat-dissipating place.

2. Battery charging as you use it

① The battery is most afraid of power loss. Keeping the battery fully charged can extend the life of the battery.

② When charging, the indicator light of the charger is red first and then green. After the light turns green, it should be guaranteed to float for 2 hours, which is good for inhibiting battery sulfide.

3. Prevent battery overcharging

① Overcharging of the battery produces a large amount of gas to flush the plate, accelerate the shedding of active substances on the plate, and shorten the life of the battery.

② Overcharging of the battery accelerates water loss, causing the electrolyte to dry up, the battery temperature to rise, causing thermal runaway, plate expansion, and shell deformation.

4. Prevent battery over-discharge

Being skillful in using battery vehicles can also extend the battery life. Long-term deep discharge will cause the battery plates to soften and shorten the service life.

①Prevent high current discharge. When starting, going uphill and driving against the wind, try to use your feet to assist.

②Prevent long-term discharge. Do not often run with full discharge. Recharge when the power is reduced by 1/2.

5. Prevent battery loss

For batteries that have been shelved for a long time, they should be fully charged once a month. Generally, it is best to continue floating charging for 5 hours after the charger turns red to green.

6. Frequent battery care

Although the battery of the Hydraulic Dumping Tricycle is maintenance-free, after the battery is used for half a year, as the water is continuously consumed, the plate will be sulfided and softened, which will cause the battery capacity to decrease or even fail. Replenish water or add a small coppersmith battery activator in time to extend the battery life to more than two years.

Author:

Mr. Liu

E-mail:

liuyang@cqzonlon.com

Phone/WhatsApp:

+8613608399736